Product ID:2345A GREEN PRIMER, PARAT A
MSDS Date:12/20/1994
FSC:8010
NIIN:01-347-0916
Kit Part:Y
MSDS Number: BWSZN

NILES CHEMICAL PAINT CO

225 FORT STREET
NILES, MI 49120
US

Emergency Phone: 219-236-5856

Info Phone: 616-683-3377

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

TALC

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: 42%

BUTYL ALCOHOL (SARA 313) (CERCLA) (VAPOR PRESSURE 4.4 MM HG

CAS: 71-36-3

RTECS: EO1400000

Fraction By Weight: 27%

OSHA PEL 50 PPM

ACGIH TLV: 50 PPM (SKIN)

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

POLYAMIDE/EPOXY ADDUCT

Fraction By Weight: 17.6%

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 8%

AMIDOAMINE-RESIN

CAS: 68443-08-3

Fraction By Weight: 100%

PROPRIETARY INGREDIENTS (MFR STATES UNIDENTIFIED

Fraction By Weight: BALANCE

3.24 LBS/GAL

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: SEVERE IRRITATION, TEARING,
REDNESS, BLURRED VISION. SKIN: HARMFUL IF ABSORBED. INHAL: NASAL &
RESP IRRITATION. CNS DEPRESSION
(DIZZY,DROWSY,WEAK,FATIGUE,CONFUSION) NAUSEA, HEADACHE, VERTIGO,
UNC ONSCIOUSNESS, ASPHYXIATION. INGEST: GI IRRITATION, ABDOMINAL
PAIN, NAUSEA, VOMITING, DIARRHEA.
Effects of Overexposure:CHRONIC: LIVER, KIDNEYS, NS, RESPIRATORY TRACT.
DUST MAY CAUSE PNUEMONCONIOSIS, LEURAL THICKENING, CORNEAL
INFLAMMATION, PHOTOPHOBIA, INCOHERENCE, CORNEAL VACUOLIZATION,
ANOREXIA.
Medical Cond Aggravated by Exposure:NONE KNOWN
TARGET
ORGANS: LIVER, KIDNEYS, NS, LUNGS, SKIN, EYES, RESPIRATORY SYSTEM,
CNS, GI TRACT, BLOOD, KIDNEY.

First Aid:MOVE TO FRESH AIR IMMED. IF BREATH STOPPED, GIVE ARTIF
RESPRTN. GET MED AID ASAP. SKIN: IMMED FLUSH W/WATER. GET MED AID.
WASH CLOTH & DECONTAMINATE SHOES BEFORE REUSE. EYE: IMMED FLUSH
W/WATER AT LEA ST 15 MIN, LIFTING LID. GET MED AID IMMED. DON'T
WEAR CONTACTS WHEN WORKING W/MAT'L. INGEST: DRINK 1-2 GLASSES
WATER. DO NOT INDUCE VOMIT. CONSULT DR OR POISON CONTROL CTR IMMED.
TREAT SYMPTOMATICALY.

Flash Point Method:TCC
Flash Point:79.0F,26.1C
Lower Limits:1.0
Upper Limits:11.0
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACEPIECE (POSITIVE PRESSURE
MODE) & FULL PROTECT CLOTH. USE WATER TO COOL CLOSED CNTNR TO
PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. VAPOR HEAVIER THAN AIR,
TRAVEL ON GRND TO IGNIT SOURCE. NO HEAT/IGNIT. CLSD CNTNRS MAY
EXPLODE W/HEAT. APP TO HOT SRFC REQUIRE SPCL PRECAUTIONS

Spill Release Procedures:ELIMINATE IGNITION SOURCE. MINIMIZE BREATHING
VAPOR/AVOID SKIN CONTACT. SMALL:ABSORB W/INERT MAT'L
(CLAY,SOIL,COMMERCIAL ABSORBENT). SHOVEL RECLAIMED LIQ/ABSORBENT
INTO RECOVERY/SALVAGE DRUMS. LRG:DIK E. RECLAIM INTO
RECOVERY/SALVAGE DRUMS/TANK TRUCK.

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURE
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF MATERIAL MAY BE HAZARDOUS WHEN EMPTY.
DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING MAY
SPLIT CONTAINER.

Respiratory Protection:WEAR APPROPRIATE (TYPE TC-23C-75) FITTED
HALF-MASK OR FULL FACEPIECE RESPIRATOR DURING/AFTER APPLICATION
UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVEL BELOW
APPLICALBE LIMITS. FOLLOW RESPIRATOR MFR'S DIRECTIONS FOR USE.
Ventilation:KEEP BELOW PEL/TLV. REMOVE DECOMP FROM WELD/FLAME CUTTING
SURFACES COATED W/PRODUCT. VENT VAPORS FROM BAKING FINISHES.
Protective Gloves:CHEMICAL RESISTANT (NITRILE/VITON)GLOVES
Eye Protection:CHEM GOGGLES,SAFETY GLASSES,FACE SHIELDS
Other Protective Equipment:WEAR CHEMICAL RESISTANT (NITRILE OR VITON)
CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH HANDS BEFORE EATING, SMOKING, OR USING
RESTROOM. EMPLOYEES SHOULD WASH PROMPTLY WHEN SKIN BECOMES
CONTAMINATED.
Supplemental Safety and Health
REMOVE ANY CLOTHING THAT BECOMES WET (TO AVOID FLAMMABILITY HAZARD) AND
WASH BEFORE REUSE.

HCC:F3
Boiling Pt:B.P. Text:242 TO 325F
Vapor Density:> AIR
Spec Gravity:1.398
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:48.05
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
WILL SOFTEN POLYETHYLENE, OLYPROPYLENE, VC CONTAINERS, OXIDIZERS,
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND/OR
CARBON DIOXIDE
Conditions to Avoid Polymerization:HIGH TEMPERATURES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULAITONS. EPA HAZARDOUS WASTE CODE: D001
(IGNITABLE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.